Artículo

Estamos trabajando para incorporar este artículo al repositorio
Consulte el artículo en la página del editor
Consulte la política de Acceso Abierto del editor

Abstract:

An anisotropic magnetorheological composite formed by dispersions of silver-covered magnetite microparticles (Fe3O4@Ag) in polydimethylsiloxane (PDMS) displaying electrical conduction only in one preferred direction is presented. A set-up for applying and detecting electrical conduction through the composite is described and applied to characterize the behavior of the system in on-off commutation cycles. The composite is obtained by loading the polymer with relatively low concentration of fillers (5%, w/w of the total weight) and curing it in the presence of a uniform magnetic field. The fillers appear in the final composite as an array of needles, i.e. pseudo-chains of particles aligned in the direction of the magnetic field. Using Fe3O4 nanoparticles (13 nm) it is possible to obtain cured composites in a superparamagnetic state, that is, without magnetic hysteresis at room temperature. Hysteresis is not found in the elastic properties either; in particular, Mullins effects (change of physical properties after the first strain-stress cycle) were not observed. No measurable transversal electrical conduction was detected (transversal resistivity larger than 62 MΩ cm). Thus, significant electrical conductivity is present only between contact points that are exactly facing each other at both sides of the composites in the direction parallel to the needles. The I-V curves in that direction have ohmic behavior and exhibit both piezoresistance and magnetoresistance, that is, the electrical conductivity in the direction parallel to the pseudo-chains increases when a pressure (i.e. compressive stress) is applied at constant magnetic field and/or when a magnetic field is applied at constant pressure. The materials do not exhibit magnetoelectric or piezoresistive hysteresis. These characteristics illustrate the high potentiality of these systems in elastic connectors where electrical conduction can be varied by external mechanical or magnetic forces. © 2012 Elsevier B.V.

Registro:

Documento: Artículo
Título:Superparamagnetic anisotropic elastomer connectors exhibiting reversible magneto-piezoresistivity
Autor:Mietta, J.L.; Jorge, G.; Perez, O.E.; Maeder, T.; Negri, R.M.
Filiación:Instituto de Química Física de Materiales, Ambiente y Energía (INQUIMAE), Departamento de Química Inorgánica, Analítica y Química Física, Universidad de Buenos Aires, Argentina
Departamento de Física, Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Argentina
Departamento de Industrias, Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Argentina
Laboratoire de Production Microtechnique, (LPM), École Polytechnique Fédérale de Lausanne (EPFL), Lausanne, Switzerland
Palabras clave:Magnetoelastomers; Magnetoresistivity; Piezoresistivity; Anisotropic elastomers; Constant magnetic fields; Constant pressures; Contact points; Elastic properties; Electrical conduction; Electrical conductivity; I - V curve; Low concentrations; Magnetic force; Magneto-rheological; Magnetoelastomers; Micro-particles; Mullins effect; Ohmic behavior; Piezo-resistive; Piezoresistance; Piezoresistivity; Polydimethylsiloxane PDMS; Room temperature; Superparamagnetic state; Superparamagnetics; Anisotropy; Curing; Electric conductivity; Fillers; Hysteresis; Magnetoresistance; Needles; Silicones; Superparamagnetism; Magnetic fields
Año:2013
Volumen:192
Página de inicio:34
Página de fin:41
DOI: http://dx.doi.org/10.1016/j.sna.2012.12.018
Título revista:Sensors and Actuators, A: Physical
Título revista abreviado:Sens Actuators A Phys
ISSN:09244247
CODEN:SAAPE
Registro:https://bibliotecadigital.exactas.uba.ar/collection/paper/document/paper_09244247_v192_n_p34_Mietta

Referencias:

  • Wang, J., Scampicchio, M., Laocharoensuk, R., Valentini, F., González- García, O., Burdick, J., Magnetic tuning of the electrochemical reactivity through controlled surface orientation of catalytic nanowires (2006) Journal of the American Chemical Society, 128, pp. 4562-4563
  • Mefford, O.T., Carroll, M.R.J., Vadala, M.L., Goff, J.D., Mejia-Ariza, R., Saunders, M., Size analysis of PDMS-magnetite nanoparticle complexes: Experiment and theory (2008) Chemistry of Materials, 20, pp. 2184-2191
  • Lappas, A., Zorko, A., Wortham, E., Das, R.N., Giannelis, E.P., Cevc, P., Low-energy magnetic excitations and morphology in layered hybrid perovskite-poly(dimethylsiloxane) nanocomposites (2005) Chemistry of Materials, 17, pp. 1199-1207
  • Lanotte, L., Ausanio, G., Hison, C., Iannotti, V., Luponio, C., The potentiality of composite elastic magnets as novel materials for sensors and actuators (2003) Sensors and Actuators A: Physical, 106, pp. 56-60
  • Farshad, M., Benine, A., Magnetoactive elastomer composites (2004) Polymer Testing, 23, pp. 347-353
  • Varga, Z., Filipcsei, G., Zrínyi, M., Smart composites with controlled anisotropy (2005) Polymer, 46, pp. 7779-7787
  • Varga, Z., Filipcsei, G., Zrínyi, M., Magnetic field sensitive functional elastomers with tuneable elastic modulus (2006) Polymer, 47, pp. 227-233
  • Jacobo, S.E., Aphesteguy, J.C., Lopez Anton, R., Schegoleva, N.N., Kurlyandskaya, G.V., Influence of the preparation procedure on the properties of polyaniline based magnetic composites (2007) European Polymer Journal, 43, pp. 1333-1346
  • Filipcsei, G., Csetneki, I., Szilágyi, A., Zrínyi, M., Magnetic field-responsive smart polymer composites (2007) Advances in Polymer Science, 206, pp. 137-189
  • Kchit, N., Bossis, G., Piezoresistivity of magnetorheological elastomers (2008) Journal of Physics Condensed Matter, 20, pp. 204136-204141
  • Denver, H., Heiman, T., Martin, E., Gupta, A., Borca-Tasciuc, D.-A., Fabrication of polydimethylsiloxane composites with nickel nanoparticle and nanowire fillers and study of their mechanical and magnetic properties (2009) Journal of Applied Physics, 106, pp. 64909-64914
  • Record, P., Popov, C., Fletcher, J., Abraham, E., Huang, Z., Chang, H., Direct and converse magnetoelectic effect in laminate bonded Terfenol-D-PZT composites (2007) Sensors and Actuators B: Chemical, 126, pp. 344-349
  • Keshoju, K., Sun, L., Mechanical characterization of magnetic nanowire-polydimethylsiloxane composites (2009) Journal of Applied Physics, 105, pp. 23515-23520
  • Mietta, J.L., Ruiz, M.M., Antonel, P.S., Perez, O., Butera, A., Jorge, G., Martín Negri, R., Anisotropic magnetoresistance and piezoresistivity in structured Fe 3O4-silver particles in PDMS elastomers at room temperature (2012) Langmuir, 28, pp. 6985-6996
  • Soledad Antonel, P., Jorge, G., Perez, O.E., Butera, A., Gabriela Leyva, A., Martín Negri, R., Magnetic and elastic properties of CoFe2O4- polydimethylsiloxane magnetically oriented elastomer nanocomposites (2011) Journal of Applied Physics, 110. , pp. 043920-043920-8
  • Negri, R.M., Rodriguez, S.D., Bernik, D.L., Molina, F.V., Pilosof, A., Perez, O., A model for the dependence of the electrical conductance with the applied stress in insulating-conducting composites (2010) Journal of Applied Physics, 107, pp. 113703-113714
  • Antonel, P.S., Negri, R.M., Leyva, A.G., Jorge, G.A., Anisotropy and relaxation processes of uniaxially oriented CoFe 2O4 nanoparticles dispersed in PDMS (2012) Physica B: Condensed Matter, 407, pp. 3165-3167
  • Knobel, M., Nunes, W.C., Socolovsky, L.M., De Biasi, E., Vargas, J.M., Denardin, J.C., Superparamagnetism and other magnetic features in granular materials: A review on ideal and real systems (2008) Journal of Nanoscience and Nanotechnology, 8, pp. 2836-2857
  • Coquelle, E., Bossis, G., Szabo, D., Giulieri, F., Micromechanical analysis of an elastomer filled with particles organized in chain-like structure (2006) Journal of Materials Science, 41, pp. 5941-5953
  • Coquelle, E., Bossis, G., Mullins effect in elastomers filled with particles aligned by a magnetic field (2006) International Journal of Solids and Structures, 43, pp. 7659-7672
  • Diani, J., Fayolle, B., Gilormini, P., A review on the Mullins effect (2009) European Polymer Journal, 45, pp. 601-612
  • Inglis, D.W., A method for reducing pressure-induced deformation in silicone microfluidics (2010) Biomicrofluidics, 4, pp. 026504-026508
  • Lee, D.-W., Choi, Y.-S., A novel pressure sensor with a PDMS diaphragm (2008) Microelectronic Engineering, 85, pp. 1054-1058
  • Cheng, Q., Sun, Z., Meininger, G.A., Almasri, M., Note mechanical study of micromachined polydimethylsiloxane elastic microposts (2010) Review of Scientific Instruments, 81. , pp. 106104-106104-3
  • Tong, J., Simmons, C.A., Sun, Y., Precision patterning of PDMS membranes and applications (2008) Journal of Micromechanics and Microengineering, 18, pp. 701-705
  • Bica, I., The influence of hydrostatic pressure and transverse magnetic field on the electric conductivity of the magnetorheological elastomers (2012) Journal of Industrial and Engineering Chemistry, 18, pp. 483-486
  • Wang, X., Gordaninejad, F., Calgar, M., Liu, Y., Sutrisno, J., Fuchs, A., Sensing behavior of magnetorheological elastomers (2009) Journal of Mechanical Design, 131, pp. 91004-91010
  • Martin, J.E., Anderson, R.A., Odinek, J., Adolf, D., Williamson, J., Controlling percolation in field-structured particle composites: Observations of giant thermoresistance, piezoresistance, and chemiresistance (2003) Physical Review B, 67, pp. 94207-94218

Citas:

---------- APA ----------
Mietta, J.L., Jorge, G., Perez, O.E., Maeder, T. & Negri, R.M. (2013) . Superparamagnetic anisotropic elastomer connectors exhibiting reversible magneto-piezoresistivity. Sensors and Actuators, A: Physical, 192, 34-41.
http://dx.doi.org/10.1016/j.sna.2012.12.018
---------- CHICAGO ----------
Mietta, J.L., Jorge, G., Perez, O.E., Maeder, T., Negri, R.M. "Superparamagnetic anisotropic elastomer connectors exhibiting reversible magneto-piezoresistivity" . Sensors and Actuators, A: Physical 192 (2013) : 34-41.
http://dx.doi.org/10.1016/j.sna.2012.12.018
---------- MLA ----------
Mietta, J.L., Jorge, G., Perez, O.E., Maeder, T., Negri, R.M. "Superparamagnetic anisotropic elastomer connectors exhibiting reversible magneto-piezoresistivity" . Sensors and Actuators, A: Physical, vol. 192, 2013, pp. 34-41.
http://dx.doi.org/10.1016/j.sna.2012.12.018
---------- VANCOUVER ----------
Mietta, J.L., Jorge, G., Perez, O.E., Maeder, T., Negri, R.M. Superparamagnetic anisotropic elastomer connectors exhibiting reversible magneto-piezoresistivity. Sens Actuators A Phys. 2013;192:34-41.
http://dx.doi.org/10.1016/j.sna.2012.12.018