Abstract:
The extent of liquid back-mixing in gas-liquid concurrent upflow packed-bubble column reactors is quantified in terms of an axial dispersion coefficient or its corresponding dimensionless Peclet number. Effects of reactor operating conditions on the axial dispersion coefficient are not properly accounted for by the available literature correlations, wherein most often the Peclet number is expressed solely in terms of the gas and liquid Reynolds numbers or superficial velocities. Based on the broadest experimental databank (1322 measurements, 11 liquids, four gases, 28 packing materials, 14 columns diameters, Newtonian, non-Newtonian, aqueous, organic, coalescing and non-coalescing liquids, high pressure, bubble and pulsing flow regime conditions), a state-of-the-art liquid axial dispersion coefficient correlation is obtained by combining neural network modeling and dimensional analysis. Thorough qualitative and quantitative analyses of the constructed databank demonstrate the robustness of the proposed correlation to restore the variety of trend variations of liquid Peclet numbers reported in the literature.
Registro:
Documento: |
Artículo
|
Título: | Liquid back-mixing in packed-bubble column reactors: A state-of-the-art correlation |
Autor: | Belfares, L.; Cassanello, M.; Grandjean, B.P.A.; Larachi, F. |
Filiación: | Department of Chemical Engineering, CERPIC, Université Laval, Ste-Foy, Que. G1K 7P4, Canada PINMATE, Departmento de Industrias, Ciudad Universitaria, 1428 Buenos Aires, Argentina
|
Palabras clave: | Bubble columns; Chemical reactions; Neural networks; Newtonian liquids; Non Newtonian liquids; Packed beds; Reynolds number; Liquid back-mixing; Peclet number; Catalyst activity |
Año: | 2001
|
Volumen: | 64
|
Número: | 3-4
|
Página de inicio: | 321
|
Página de fin: | 332
|
DOI: |
http://dx.doi.org/10.1016/S0920-5861(00)00535-6 |
Título revista: | Catalysis Today
|
Título revista abreviado: | Catal Today
|
ISSN: | 09205861
|
CODEN: | CATTE
|
Registro: | https://bibliotecadigital.exactas.uba.ar/collection/paper/document/paper_09205861_v64_n3-4_p321_Belfares |
Referencias:
- Germain, A., L'Homme, G.A., Lefebvre, A., (1979) Chemical Engineering of Gas-Liquid-Solid Catalyst Reactions, p. 265. , G.A. L'Homme (Ed.), CEBEDOC, Liège, Belgium
- Trambouze, P., (1991) Rev. Inst. Franç. Petr., 46, p. 433
- Van Gelder, K.B., Damhof, J.K., Westerterp, K.R., (1990) Chem. Eng. Sci., 45, p. 3171
- Stüber, F., Wilhelm, A.M., Delmas, H., (1996) Chem. Eng. Sci., 51, p. 2161
- Sie, S.T., (1991) Rev. Inst. Franç. Petr., 46, p. 501
- Thanos, A.M., Menagias, P., Galtier, P.A., Papayannakos, N.G., (1999) Ind. Eng. Chem. Res., 38, p. 3817
- Bensetiti, Z., Larachi, F., Grandjean, B.P.A., Wild, G., (1997) Chem. Eng. Sci., 52, p. 4239
- Larachi, F., Bensetiti, Z., Grandjean, B.P.A., Wild, G., (1998) Chem. Eng. Technol., 21, p. 887
- Gianetto, A., Baldi, G., Specchia, V., Sicardi, S., (1978) AIChE J., 24, p. 1087
- Shah, Y.T., (1979) Gas-Liquid-Solid Reactor Design, , McGraw-Hill, New York
- Zhukova, T.B., Pisarenko, V.N., Kafarov, V.V., (1990) Int. Chem. Eng., 30, p. 57
- Bill, W., (1955) Diplomarbeit, , Technischen Hochschule, Darmstadt, Germany
- Weber, H.H., (1961) Untersuchungen Über die Verweilzeitverteilung in Aufstromkolonnen, , Ph.D. Dissertation, Technischen Hochschule, Darmstadt, Germany
- Von Heilmann, W., Hofmann, H., (1969) Proceedings of the Fourth European Symposium Chemical Reactor Engineering, p. 169. , Brussels, Belgium
- Bezdenezhnykh, A.A., Taranov, V.I., Orlov, A.P., (1971) Teor. Osn. Khim. Tekhnol., 5, p. 163
- Stiegel, G.J., Shah, Y.T., (1977) Ind. Eng. Chem. Process. Des. Dev., 16, p. 37
- Stiegel, G.J., Shah, Y.T., (1977) Can. J. Chem. Eng., 55, p. 3
- Achwal, S.K., Stepanek, J.B., (1979) Can. J. Chem. Eng., 57, p. 409
- Van Gelder, K.B., Westerterp, K.R., (1990) Chem. Eng. Technol., 13, p. 27
- Thanos, A.M., Galtier, P.A., Papayannakos, N.G., (1996) Chem. Eng. Sci., 51, p. 2709
- Cassanello, M.C., (1992) Caracterización Fluidodinámica de Reactores Trifásicos de Lecho Fijo, , Ph.D. Thesis, Universidad de Buenos Aires, Buenos Aires, Argentina
- Cassanello, M., Martinez, O., Cukierman, A.L., (1998) Chem. Eng. Sci., 53, p. 1015
- Shah, Y.T., Stiegel, G.J., Sharma, M.M., (1978) AIChE J., 24, p. 369
- Skomorokov, V.B., Kirillov, V.A., Baldi, G., (1986) Chem. Eng. J., 33, p. 169
- Illiuta, I., Thyrion, F.C., Muntean, O., Gigot, M., (1996) Chem. Eng. Sci., 51, p. 4579
- Yang, X.-L., Euzen, J.P., Wild, G., (1990) Chem. Eng. Sci., 45, p. 3311
- Yang, X.-L., (1989) Études Hydrodynamiques des Réacteurs À Lit Fixe Avec Écoulement Co-courant Ascendant de Gaz et de Liquide, , Ph.D. Thesis, Université Pierre et Marie Curie (Paris IV) and ENSPM, France
- Illiuta, I., Thyrion, F.C., Muntean, O., (1998) Trans. Inst. Chem. Eng., 76, p. 64
- Illiuta, I., Thyrion, F.C., Bolle, L., Giot, M., (1997) Chem. Eng. Technol., 20, p. 171
- Iliuta, I., Larachi, F., Grandjean, B.P.A., (1999) Chem. Eng. Sci., 54, p. 4099
- Haga, K., Niibori, Y., Childa, T., (1999) Water Resour. Res., 35, p. 1065
- Thanos, A.M., Galtier, P.A., Papayannakos, N.G., (1999) Chem. Eng. Sci., 54, p. 2781
- Kirillov, V.A., Kasamanyan, M.A., Kuzin, V.A., (1975) Theoret. Fundam. Chem. Eng., 9, p. 870
- Stüber, F., (1995) Sélectivité en Réacteur Catalytique Triphasique: Analyse Expérimentale et Théorique D'hydrogénations Consécutives en Lit Fixe Catalytique À Co-courant Ascendant de Gaz et de Liquide, , Ph.D. Thesis, Institut National Polytechnique de Toulouse, France
- Syaiful, (1993) Réacteurs Polyphasiqueà Co-courant Ascendant : Influence de la Viscosité Sur les Rétentions, Dispersions Axiales, et Transfert Gaz-liquide', , Ph.D. Thesis, Institut National Polytechnique de Toulouse, France
Citas:
---------- APA ----------
Belfares, L., Cassanello, M., Grandjean, B.P.A. & Larachi, F.
(2001)
. Liquid back-mixing in packed-bubble column reactors: A state-of-the-art correlation. Catalysis Today, 64(3-4), 321-332.
http://dx.doi.org/10.1016/S0920-5861(00)00535-6---------- CHICAGO ----------
Belfares, L., Cassanello, M., Grandjean, B.P.A., Larachi, F.
"Liquid back-mixing in packed-bubble column reactors: A state-of-the-art correlation"
. Catalysis Today 64, no. 3-4
(2001) : 321-332.
http://dx.doi.org/10.1016/S0920-5861(00)00535-6---------- MLA ----------
Belfares, L., Cassanello, M., Grandjean, B.P.A., Larachi, F.
"Liquid back-mixing in packed-bubble column reactors: A state-of-the-art correlation"
. Catalysis Today, vol. 64, no. 3-4, 2001, pp. 321-332.
http://dx.doi.org/10.1016/S0920-5861(00)00535-6---------- VANCOUVER ----------
Belfares, L., Cassanello, M., Grandjean, B.P.A., Larachi, F. Liquid back-mixing in packed-bubble column reactors: A state-of-the-art correlation. Catal Today. 2001;64(3-4):321-332.
http://dx.doi.org/10.1016/S0920-5861(00)00535-6